- 著者
- Tokuma Fukuoka Tomotake Morita Azusa Saika Hiroshi Habe
- 出版者
- Japan Oil Chemists' Society
- 雑誌
- Journal of Oleo Science (ISSN:13458957)
- 巻号頁・発行日
- vol.67, no.12, pp.1609-1616, 2018 (Released:2018-12-01)
- 参考文献数
- 26
- 被引用文献数
- 5 12
Surface properties of cast films of poly(lactic acid) (PLA) containing 1 wt% of several glycolipid-type biosurfactants (BSs) were investigated. The wettability of PLA films containing a homologue of mannosylerythritol lipids (MEL-B), lactone-form sophorolipid (LSL), or cellobiose lipid (CL) was drastically higher than that of untreated PLA and several synthetic surfactants-containing PLA. Surface wettability was also dependent on the hydrophilicity of the substrate used during solvent casting of the PLA films. The wetting behavior of the opposing sides of MEL-B-containing films prepared on glass substrates differed significantly; the contact angle on the side of the film that had been in contact with the glass surface was significantly lower than that obtained on the side of the film that had been in contact with air. Time-of-flight secondary ion mass spectrometry (TOF-SIMS) analysis results showed that the MEL in MEL-B-containing thin PLA cast films was localized to a thin surface layer. These results suggest self-assembly of MEL-B and micro-phase separation between the PLA matrix and MEL-B domains. This resulted in the localization and orientation of MEL-B at the surface of the cast PLA film, which determined its specific wetting behavior.
- 著者
- Shun Sato Tokuma Fukuoka Azusa Saika Tatsuyuki Koshiyama Tomotake Morita
- 出版者
- Japan Oil Chemists' Society
- 雑誌
- Journal of Oleo Science (ISSN:13458957)
- 巻号頁・発行日
- vol.68, no.12, pp.1287-1294, 2019 (Released:2019-12-01)
- 参考文献数
- 16
- 被引用文献数
- 11
We applied matrix-assisted laser desorption/ionization time-of-flight mass spectrometry (MALDI-TOF/MS) to screen for glycolipid-type biosurfactant (BS) producers. A crude extract of Pseudozyma antarctica, a well-known mannosylerythritol lipid (MEL) producer, was initially subjected to MALDI-TOF/MS. The spectrum of the extract showed the accumulation of diacylated MELs in culture. We then screened 80 environmental samples for BS-producing yeasts, and extracts from broth cultures of the selected five strains were examined using MALDI-TOF/MS. The results showed that all five strains produced MELs, whereas four strains also produced cellobiose lipids (CLs). By D1/D2 region sequence analysis, the MEL-producing strain was assigned to P. antarctica while the four MEL- and CL-producing strains were assigned to P. hubeiensis. These results demonstrate that MALDI-TOF/MS is a rapid and reliable tool to detect BS molecules in crude extracts of broth cultures to screen for glycolipid-type BS producers.