著者

近藤 千尋 佐野 広季 一宮 暢希 山根 浩二 河﨑 澄

出版者

一般社団法人 日本機械学会

雑誌

日本機械学会論文集 (ISSN:21879761)

巻号頁・発行日

vol.85, no.874, pp.18-00340, 2019 (Released:2019-06-25)

参考文献数

9

---

This paper describes how to produce a biodiesel fuel (BDF) from the waste soup of ramen noodles, especially focusing on the recovery process of the oil (triglycerides) from a large amount of waste soup or the oily wastewater disposed of by pouring it down the sink by a ramen restaurant. By combining a semi-transparent bucket (~6 L) with a cock and solvent extraction, it is shown that oil can be recovered easily from 300 or more bowls of ramen noodle waste soup, with an energy profit ratio (EPR) of more than 5.2. The initial cost of the bucket is about 1600 yen, so it has little effect on the price of the BDF produced from the oil in the ramen noodle waste soup, and it is shown that the increase in running cost to produce BDF by this method is about 2.3 yen/L if the rate of recovery of hexane (solvent) is over 99%, which is approximately equivalent to the production cost of waste-cooking-oil BDF production by previously reported methods. Furthermore, in the case of applying the proposed method based on the solvent extraction to the recovery of oil from the oily wastewater disposed of by a ramen noodle restaurant, it is shown that oil can be recovered from the waste soup of ramen noodles just after disposal as well as from the oily wastewater that spent one day in the grease trap. In the former case, EPR is 5.0, and the estimated amount of BDF is greater than 100 L/month for one restaurant. However, in the case of using the oily wastewater from the grease trap, EPR is less than 2.0 because of the reduction of yield of BDF due to a greater oxidation deterioration of the recovered oil, when the alkyl catalyst method is used. Therefore, it is desirable to recover oil from the oily wastewater at the drain pipe just after the sink.

著者

近藤 千尋 佐野 広季 山根 浩二 小坂田 潔 河崎 澄

出版者

一般社団法人 日本機械学会

雑誌

日本機械学会論文集 (ISSN:21879761)

巻号頁・発行日

vol.83, no.847, pp.16-00375, 2017 (Released:2017-03-25)

参考文献数

11

被引用文献数

1

---

This paper describes how to produce a biodiesel from the oil in the waste soup of ramen noodles, and especially clarifies an amount of oil in waste soup, the energy profit ratio (EPR) of the production of biodiesel from the oil in waste soup of ramen noodles and the engine performance of the biodiesel from waste soup of ramen noodles. As a result, from the waste pig bone (ton-kotsu) soup the recovered tri-glyceride was about 11g per a soup. The biodiesel produced from the oil in the waste soup of ramen noodles by using ordinary alkyl catalyst method has low cold flow properties, due to the high content of the saturated fatty acid methyl ester such as C16:0, C18:0 and so on. And it is estimated that the amount of BDF from a ramen noodle restaurant is about 2.4L if the customers are around 300 per day, and this means that the 9.9 kW co-generation system is able to be operated for an hour per day. About energy profit ratio analysis, if the oil separation process is improved, EPR from the waste soup to biodiesel will become higher than 5.0. Furthermore, engine test is performed by using BDF from the waste soup of ramen noodles as B5. As a result, it is shown that fuel consumption rate and emissions are almost the same as the case of using gasoil.

著者

近藤 千尋

出版者

一般社団法人 システム制御情報学会

雑誌

システム/制御/情報 (ISSN:09161600)

巻号頁・発行日

vol.65, no.6, pp.219-224, 2021-06-15 (Released:2021-12-15)

参考文献数

16

著者

小野 史和 近藤 千尋 佐野 広季 小白方 渉 江﨑 省吾 山根 浩二 河﨑 澄

出版者

一般社団法人 日本機械学会

雑誌

中国四国支部総会・講演会 講演論文集 2017.55 (ISSN:24242764)

巻号頁・発行日

pp.K0713, 2017 (Released:2017-06-19)

著者

佐野 広季 近藤 千尋 山根 浩二 小坂田 潔 河崎 澄

出版者

一般社団法人 日本機械学会

雑誌

動力・エネルギー技術の最前線講演論文集 : シンポジウム 2016.21 (ISSN:24242950)

巻号頁・発行日

pp.E231, 2016 (Released:2017-06-19)

---

This paper describes how to produce biodiesel from waste soup of ramen, especially in terms of improvement of the energy profit ratio, EPR. This time, by applying solidification of tri-glyceride it is removed from soup, then EPR become higher over than 3.5. And by applying solvent extraction, then EPR become higher over than 5.0. This value is much higher than that of production by vacuum distillation in the previous paper. Furthermore, engine test is performed by using BDF from waste soup of ramen as B5. As a result, it is shown that fuel consumption rate and emission is almost the same as the case of using gasoil.

著者

佐野 広季 近藤 千尋 山根 浩二 小坂田 潔 河崎 澄

出版者

一般社団法人 日本機械学会

雑誌

動力・エネルギー技術の最前線講演論文集 : シンポジウム

巻号頁・発行日

vol.2016, 2016

---

<p>This paper describes how to produce biodiesel from waste soup of ramen, especially in terms of improvement of the energy profit ratio, EPR. This time, by applying solidification of tri-glyceride it is removed from soup, then EPR become higher over than 3.5. And by applying solvent extraction, then EPR become higher over than 5.0. This value is much higher than that of production by vacuum distillation in the previous paper. Furthermore, engine test is performed by using BDF from waste soup of ramen as B5. As a result, it is shown that fuel consumption rate and emission is almost the same as the case of using gasoil.</p>